Make a donation
« previous next »
Pages: [1]   Go Down

Author Topic: Slight clutch slip  (Read 2039 times)

Offline kbish73

  • Taking part
  • ***
  • Thank You
  • -Given: 1
  • -Receive: 4
  • Posts: 33
Slight clutch slip
« on: February 06, 2013, 10:53:45 am »
Hi folks! Looking for some advise regards to clutch slipping . Whilst drive home from Edinburgh this morning sitting in top gear just below 3000rpm I put the foot down to pass traffic and I'm getting a small amount of slip only for a few seconds the revs rise about 500 rpm then car pulls as normal again! This only happens in top gear at this rpm can't get the car do it in any other gear or speed!
Car is 2006 gti stage 1 46k
Logged
3dr 2006 gti steel grey 18" monzas sunroof cruise control parking sensors,giac stage1,miltek cat back,Pannel filter,tarrox discs .....

Offline Hedge

  • Just look at my post count
  • ******
  • Thank You
  • -Given: 484
  • -Receive: 304
  • Posts: 6621
Re: Slight clutch slip
« Reply #1 on: February 06, 2013, 10:58:07 am »
Change down then.

You are applying maximum torque to the gear with most resistance. No wonder it slips.  :happy2:
Logged

Offline gigolo456

  • Won't Shut up.
  • *****
  • Thank You
  • -Given: 1
  • -Receive: 15
  • Posts: 746
Re: Slight clutch slip
« Reply #2 on: February 06, 2013, 11:07:04 am »
Or get an uprated clutch and do whatever you want in any gear!!  :jumping:
Logged

Offline kbish73

  • Taking part
  • ***
  • Thank You
  • -Given: 1
  • -Receive: 4
  • Posts: 33
Re: Slight clutch slip
« Reply #3 on: February 06, 2013, 11:08:24 am »
Changing down defo works but this seems to be a new issue as its never done it before in the 3yrs of ownership/mapped!
Logged
3dr 2006 gti steel grey 18" monzas sunroof cruise control parking sensors,giac stage1,miltek cat back,Pannel filter,tarrox discs .....

Offline camfollower

  • Won't Shut up.
  • *****
  • Thank You
  • -Given: 10
  • -Receive: 31
  • Posts: 556
  • Cam follower awareness.
Re: Slight clutch slip
« Reply #4 on: February 06, 2013, 11:34:59 am »
A healthy standard clutch should be able to take WOT from 3k in any gear without slippage on a Stage1 GTI.  Although it's not recommended as good practice all the time.  A medium throttle should be fine though.

An aggressively torquey map and a lot of low RPM WOT'ing will definitely reduce the amount of miles you can get out of it... you've had 3 staged years on it...
Logged

Offline I am the boost! troll

  • Just Arrived
  • **
  • Thank You
  • -Given: 3
  • -Receive: 2
  • Posts: 18
  • boostin 24/7 for the ladies.
Re: Slight clutch slip
« Reply #5 on: February 06, 2013, 11:43:16 am »
Yeah those clutches are pretty strong, im suprised your full whack in 1st gear anyway... I can't get any power down in first without wheel hop and i'm all standard :)
Logged
Golf MKV GTI 08 Standard. Remember... young females love boost.

Offline kbish73

  • Taking part
  • ***
  • Thank You
  • -Given: 1
  • -Receive: 4
  • Posts: 33
Re: Slight clutch slip
« Reply #6 on: February 06, 2013, 11:53:51 am »
Cheers for the comments folks  :happy2:
My map is quite aggressive (giac) and over time I've maybe became rather lazy relying on the torque to do the work ! Ill see how long it lasts and take it from there  :driver:
Logged
3dr 2006 gti steel grey 18" monzas sunroof cruise control parking sensors,giac stage1,miltek cat back,Pannel filter,tarrox discs .....

Offline kbish73

  • Taking part
  • ***
  • Thank You
  • -Given: 1
  • -Receive: 4
  • Posts: 33
Re: Slight clutch slip
« Reply #7 on: February 06, 2013, 11:55:30 am »
Quote from: DomMKVGTI on February 06, 2013, 11:43:16 am
Yeah those clutches are pretty strong, im suprised your full whack in 1st gear anyway... I can't get any power down in first without wheel hop and i'm all standard :)
im talking about 6th gear no way could I nail it in first it's just for moving off the mark :wink:
Logged
3dr 2006 gti steel grey 18" monzas sunroof cruise control parking sensors,giac stage1,miltek cat back,Pannel filter,tarrox discs .....

Offline I am the boost! troll

  • Just Arrived
  • **
  • Thank You
  • -Given: 3
  • -Receive: 2
  • Posts: 18
  • boostin 24/7 for the ladies.
Re: Slight clutch slip
« Reply #8 on: February 06, 2013, 11:58:09 am »
Quote from: kbish73 on February 06, 2013, 11:55:30 am
Quote from: DomMKVGTI on February 06, 2013, 11:43:16 am
Yeah those clutches are pretty strong, im suprised your full whack in 1st gear anyway... I can't get any power down in first without wheel hop and i'm all standard :)
im talking about 6th gear no way could I nail it in first it's just for moving off the mark :wink:

Ahh sorry I forget to read posts properly! Do you get lots of wheel hop and gear stick shake if you floor it in first? I think I need some stronger mounts as its always wet where I live  :drool:
Logged
Golf MKV GTI 08 Standard. Remember... young females love boost.

Offline kbish73

  • Taking part
  • ***
  • Thank You
  • -Given: 1
  • -Receive: 4
  • Posts: 33
Re: Slight clutch slip
« Reply #9 on: February 06, 2013, 12:13:45 pm »
Quote from: DomMKVGTI on February 06, 2013, 11:58:09 am
Quote from: kbish73 on February 06, 2013, 11:55:30 am
Quote from: DomMKVGTI on February 06, 2013, 11:43:16 am
Yeah those clutches are pretty strong, im suprised your full whack in 1st gear anyway... I can't get any power down in first without wheel hop and i'm all standard :)
im talking about 6th gear no way could I nail it in first it's just for moving off the mark :wink:

Ahh sorry I forget to read posts properly! Do you get lots of wheel hop and gear stick shake if you floor it in first? I think I need some stronger mounts as its always wet where I live  :drool:
cant say I do but I never nail it in first but second will spin but I just change up again !
Logged
3dr 2006 gti steel grey 18" monzas sunroof cruise control parking sensors,giac stage1,miltek cat back,Pannel filter,tarrox discs .....

Offline GrayMK5GTI

  • Global Moderator
  • Just look at my post count
  • *
  • Thank You
  • -Given: 125
  • -Receive: 248
  • Posts: 4165
Re: Slight clutch slip
« Reply #10 on: February 06, 2013, 12:40:35 pm »
Quote from: camfollower on February 06, 2013, 11:34:59 am
A healthy standard clutch should be able to take WOT from 3k in any gear without slippage on a Stage1 GTI.  Although it's not recommended as good practice all the time.  A medium throttle should be fine though.

An aggressively torquey map and a lot of low RPM WOT'ing will definitely reduce the amount of miles you can get out of it... you've had 3 staged years on it...

My GTI was slipping on day one after the remap. My Focus ST before also slipped with a remap. It does depend on the health of the clutch but I cant help thinking any mapped GTI manual will get clutch slip at some point, if not straight away.

The slip will only get worse. . . .  :sad1:
Logged
NOW: 2015 Golf R DSG 5 Door, Lapiz Blue, 19s, Discover Nav, Reversing Camera
GONE:2007 Black GTI Edition 30 3dr

Offline Hedge

  • Just look at my post count
  • ******
  • Thank You
  • -Given: 484
  • -Receive: 304
  • Posts: 6621
Re: Slight clutch slip
« Reply #11 on: February 06, 2013, 12:43:22 pm »
Quote from: camfollower on February 06, 2013, 11:34:59 am
A healthy standard clutch should be able to take WOT from 3k in any gear without slippage on a Stage1 GTI. 

Says who? Do VW say that in their documentation somewhere?
Logged

Offline camfollower

  • Won't Shut up.
  • *****
  • Thank You
  • -Given: 10
  • -Receive: 31
  • Posts: 556
  • Cam follower awareness.
Re: Slight clutch slip
« Reply #12 on: February 06, 2013, 08:38:41 pm »
Quote from: Hedge on February 06, 2013, 12:43:22 pm
Quote from: camfollower on February 06, 2013, 11:34:59 am
A healthy standard clutch should be able to take WOT from 3k in any gear without slippage on a Stage1 GTI. 
An aggressively torquey map and a lot of low RPM WOT'ing will definitely reduce the amount of miles you can get out of it... you've had 3 staged years on it...

Says who? Do VW say that in their documentation somewhere?

Thought the standard clutch was rated at ~350lb/ft - if that's more like 300lb/ft then I can see why some of these aggressively torquey maps have issues.
Bluefin is much more restrained around 250lb/ft S1 and 270lb/ft S2... perhaps they realise the problem, where other tuners simply expect customers to swap out their clutches for an S1 map! :surprised:  Adding a whole lot more expense to a simple ECU flash!
Logged

Offline TrickGTI

  • Always Involved
  • ****
  • Thank You
  • -Given: 15
  • -Receive: 16
  • Posts: 434
    • Email
Re: Slight clutch slip
« Reply #13 on: February 06, 2013, 09:45:44 pm »
A standard clutch should easily be able to handle a stage one map! As for the designers of them, they  surely wouldn't use a clutch that was rated to just above a standard cars output figures as that would mean a crappy lifespan on a standard car. There are enough stage 2+ cars that run no problem. Mine been one. I did a track day and full day drag strip all on standard clutch stage 2+ and no problems at 50k
Logged
2006 Tornado red GTI
Pages: [1]   Go Up
« previous next »