Make a donation
« previous next »
Pages: [1] 2 3   Go Down

Author Topic: Spluttering gti under load SOLVED.  (Read 15803 times)

Offline rich golf gti mk5

  • Always Involved
  • ****
  • Thank You
  • -Given: 5
  • -Receive: 2
  • Posts: 89
    • Email
Spluttering gti under load SOLVED.
« on: April 20, 2013, 08:23:49 pm »
Hi all had nothing but problems from day 1 n now I've had car for about 5 week. Right were do I start 1 st of all I replaced dv and that increased my power by loads as it was completely knackered then cam follower then a coil pack then maf sensor then my live wire goin to maf was dead so got that fixed now when u put your foot down it will splutter or misfire then take off until next gear then same again. If you give it a bit of welly for a min or 2 it will cut power and go into limp mode turn engine off then it's ok til u put foot down again. Take maf sensor out no spluttering but still goes into limp mode. I've reset engine Managment n no codes are back on even tho problems still persist. Really need this fixing any advice.
« Last Edit: April 21, 2013, 02:19:37 pm by rich golf gti mk5 »
Logged

Saintsteve

  • Guest
Re: Spluttering gti under load
« Reply #1 on: April 20, 2013, 08:25:54 pm »
Quote from: rich golf gti mk5 on April 20, 2013, 08:23:49 pm
Hi all had nothing but problems from day 1 n now I've had car for about 5 week. Right were do I start 1 st of all I replaced dv and that increased my power by loads as it was completely knackered then cam follower then a coil pack then maf sensor then my live wire goin to maf was dead so got that fixed now when u put your foot down it will splutter or misfire then take off until next gear then same again. If you give it a bit of welly for a min or 2 it will cut power and go into limp mode turn engine off then it's ok til u put foot down again. Take maf sensor out no spluttering but still goes into limp mode. I've reset engine Managment n no codes are back on even tho problems still persist. Really need this fixing any advice.

You have VCDS.. I suggest you Copy up your fault codes. :happy2:

Then peeps might be able to help you better. :happy2:


Are you remapped? Does the car do this in Stock mode?

If no codes are showing, it could well be a mechanical issue or spark plugs as this wouldn't show up in VCDS errors either.
« Last Edit: April 20, 2013, 08:29:38 pm by Saintsteve »
Logged

Offline rich golf gti mk5

  • Always Involved
  • ****
  • Thank You
  • -Given: 5
  • -Receive: 2
  • Posts: 89
    • Email
Re: Spluttering gti under load
« Reply #2 on: April 20, 2013, 08:30:08 pm »
Ok will do. How do I do this sorry I'm a newbie thanks
Logged

Saintsteve

  • Guest
Re: Spluttering gti under load
« Reply #3 on: April 20, 2013, 08:30:44 pm »
Quote from: rich golf gti mk5 on April 20, 2013, 08:30:08 pm
Ok will do. How do I do this sorry I'm a newbie thanks

Copy and paste is the easiest method ..
Logged

Offline rich golf gti mk5

  • Always Involved
  • ****
  • Thank You
  • -Given: 5
  • -Receive: 2
  • Posts: 89
    • Email
Re: Spluttering gti under load
« Reply #4 on: April 20, 2013, 08:32:43 pm »
No not mapped I don't think how do I find out. Can u do it with vagcom. I have use of vag.
Logged

Offline rich golf gti mk5

  • Always Involved
  • ****
  • Thank You
  • -Given: 5
  • -Receive: 2
  • Posts: 89
    • Email
Re: Spluttering gti under load
« Reply #5 on: April 20, 2013, 08:41:10 pm »
Mechanical such as ? I thought about changing plugs as a precaution my car also smells of petrol abit wen cold from start up does any1 else's?
Logged

Saintsteve

  • Guest
Re: Spluttering gti under load
« Reply #6 on: April 20, 2013, 09:35:43 pm »
Quote from: rich golf gti mk5 on April 20, 2013, 08:41:10 pm
Mechanical such as ? I thought about changing plugs as a precaution my car also smells of petrol abit wen cold from start up does any1 else's?

Car shouldn't smell of fuel.. They run rich on start up, so you might smell it via exhaust from cold.. As long as your oil isn a wash with fuel! You could log the MAF reading which will give u approx Hp output by multiplying the readings by by 0.80.

Have you checked the PCV valve?
Logged

Offline john87

  • Won't Shut up.
  • *****
  • Thank You
  • -Given: 11
  • -Receive: 53
  • Posts: 790
    • Email
Re: Spluttering gti under load
« Reply #7 on: April 20, 2013, 09:36:23 pm »
it will be your plugs (which you should replace if they've not been done in the last 10k miles) or, failing that, a dodgy coil pack (replace). I've had the problem twice (misfire when accelerating) first time it was plugs, second time a coil pack  :happy2:
Logged
VCDS Hex-USB +CAN (Central Scotland)

Offline rich golf gti mk5

  • Always Involved
  • ****
  • Thank You
  • -Given: 5
  • -Receive: 2
  • Posts: 89
    • Email
Re: Spluttering gti under load
« Reply #8 on: April 20, 2013, 09:46:09 pm »
been done on service book 5k agojust replaced 1 coilpack too.trying to upload faults codes now.
Logged

Offline john87

  • Won't Shut up.
  • *****
  • Thank You
  • -Given: 11
  • -Receive: 53
  • Posts: 790
    • Email
Re: Spluttering gti under load
« Reply #9 on: April 20, 2013, 09:54:48 pm »
 :popcornsoda:
Logged
VCDS Hex-USB +CAN (Central Scotland)

Offline rich golf gti mk5

  • Always Involved
  • ****
  • Thank You
  • -Given: 5
  • -Receive: 2
  • Posts: 89
    • Email
Re: Spluttering gti under load
« Reply #10 on: April 20, 2013, 09:58:06 pm »

09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: Malfunction 1010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
37-Navigation -- Status: Not registered 0011
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: Malfunction 0010
 
-------------------------------------------------------------------------------
Address 01: Engine        Labels: 06F-907-115-AXX.lbl
   Part No SW: 1K0 907 115 A    HW: 1K0 907 115 A
   Component: 2.0l R4/4V TFSI G00 0070 
   Revision: --H01---    Serial number: VWZ7Z0E2173747
   Coding: 040300031C070160
   Shop #: WSC 00187 210 89766
   VCID: 2441A30BE7548338654
Logged

Offline rich golf gti mk5

  • Always Involved
  • ****
  • Thank You
  • -Given: 5
  • -Receive: 2
  • Posts: 89
    • Email
Re: Spluttering gti under load
« Reply #11 on: April 20, 2013, 09:59:19 pm »

Readiness: 0010 0001

-------------------------------------------------------------------------------
Address 02: Auto Trans        Labels: 02E-300-0xx.lbl
   Part No SW: 02E 300 042 Q    HW: 02E 927 770 AD
   Component: GSG DSG         070 0925 
   Revision: 04007000    Serial number: 00000504260321
   Coding: 0000020
   Shop #: WSC 01279 785 00200
   VCID: 214FAA1FF84696100E2

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes        Labels: 1K0-907-379-MK60-F.lbl
   Part No SW: 1K0 907 379 Q    HW: 1K0 907 379 Q
   Component: ESP FRONT MK60      0102 
   Revision: 00T12001   
   Coding: 0004738
   Shop #: WSC 01279 785 00200
   VCID: 40890F9B130CBF1861C

1 Fault Found:
01309 - Power Steering Control Module (J500)
            008 - Implausible Signal - Intermittent

-------------------------------------------------------------------------------
Address 08: Auto HVAC        Labels: 1K0-907-044.lbl
   Part No SW: 1K0 907 044 BJ    HW: 1K0 907 044 BJ
   Component: ClimatronicPQ35 090 0909 
   Revision: 00090016    Serial number: 00000000000000
   Shop #: WSC 00000 000 00000
   VCID: 70E99F5B632C6F98D1C

2 Faults Found:
00756 - Left Vent Temp Sensor (G150)
            010 - Open or Short to Plus
00229 - Refrigerant Pressure
            002 - Lower Limit Exceeded

-------------------------------------------------------------------------------
Address 09: Cent. Elect.        Labels: 3C0-937-049-23-H.lbl
   Part No SW: 3C0 937 049 E    HW: 3C0 937 049 E
   Component: Bordnetz-SG     H37 1002 
   Revision: 00H37000    Serial number: 00000001834378
   Coding: E68D8F2700041800001400001400000000097F075C
   Shop #: WSC 00558 210 00001
   VCID: 2B5348378A8A4C40A4E

   Subsystem 1 - Part No: 1K2 955 119 C  Labels: 1KX-955-119.CLB
   Component: Wischer VW350  012  0402 
   Coding: 00065493
   Shop #: WSC 00558 

   Subsystem 2 - Part No: 1K0 955 559 R  Labels: 1K0-955-559-AF.CLB
   Component: RegenLichtSens 010  1010 
   Coding: 00207646
   Shop #: WSC 00558 

10 Faults Found:
00061 - Footwell Lights
            012 - Electrical Fault in Circuit
02498 - Left Low Beam Reflector Motor (V294)
            012 - Electrical Fault in Circuit
02499 - Right Low Beam Reflector Motor (V295)
            012 - Electrical Fault in Circuit
02092 - Enabling Heated Seat
            009 - Open or Short to Ground
00906 - Horn (H1)
            009 - Open or Short to Ground - Intermittent
02071 - Local Databus
            004 - No Signal/Communication - Intermittent
01321 - Control Module for Airbags (J234)
            004 - No Signal/Communication - Intermittent
01320 - Control Module for Climatronic (J255)
            004 - No Signal/Communication - Intermittent
02389 - Release Signal Transmission; Position P/N
            008 - Implausible Signal - Intermittent
01520 - Rain and Light Recognition Sensor (G397)
            004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 15: Airbags        Labels: 1K0-909-605.lbl
   Part No SW: 1K0 909 605 N    HW: 1K0 909 605 N
   Component: 08 AIRBAG VW8   015 2100 
   Revision: 03015000    Serial number: 0038ED0DMTT2 
   Coding: 0012344
   Shop #: WSC 01279 785 00200
   VCID: 377B644746C2F8A0D06

1 Fault Found:
00532 - Supply Voltage B+
            002 - Lower Limit Exceeded - Intermittent

-------------------------------------------------------------------------------
Address 16: Steering wheel        Labels: 1K0-953-549-MY8.lbl
   Part No SW: 1K0 953 549 AG    HW: 1K0 953 549 AG
   Component: J0527           634 0070 
   Coding: 0012122
   Shop #: WSC 01279 785 00200
   VCID: 77FBA447064238A0106

   Part No: XXXXXXXXXXX
   Component: E0221           007 0050

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments        Labels: 1K0-920-xxx-17.lbl
   Part No: 1K6 920 962
   Component: KOMBIINSTRUMENT VDD 1012 
   Coding: 0024403
   Shop #: WSC 00999 444 64523
   VCID: EED50123F918F968430

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway        Labels: 1K0-907-530-V1.clb
   Part No SW: 1K0 907 530 F    HW: 1K0 907 951
   Component: Gateway         H10 0120 
   Revision:   H10       Serial number: 280010551901DE
   Coding: 3F0F0340070001
   Shop #: WSC 01279 785 00200
   VCID: 2A5D4D33857055485F8

4 Faults Found:
01044 - Control Module Incorrectly Coded
            000 -  -
01315 - Transmission Control Module 
            004 - No Signal/Communication - Intermittent
01320 - Control Module for Climatronic (J255)
            004 - No Signal/Communication - Intermittent
01321 - Control Module for Airbags (J234)
            004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 25: Immobilizer        Labels: 1K0-920-xxx-25.clb
   Part No: 1K6 920 962
   Component: IMMO            VDD 1012 
   Shop #: WSC 00000 000 00000
   VCID: EED50123F918F968430

No fault code found.

-------------------------------------------------------------------------------
Address 37: Navigation (J0506)       Labels: 1T0-035-680.clb
   Part No SW: 1T0 035 680 B    HW: 1T0 035 680 B
   Component: RNS-MID       H03 0800 
   Revision: AB001001    Serial number: VWZ6Z7H7178053
   Coding: 040004000400001200
   Shop #: WSC 00020 790 00000
   ASAM Dataset: ------------------------- ------
   VCID: 2D57462F749E4270BAA

3 Faults Found:
00856 - Radio Antenna
            011 - Open Circuit
03138 - Input AUX IN
            011 - Open Circuit - Intermittent
01299 - Diagnostic Interface for Data Bus (J533)
            004 - No Signal/Communication

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver        Labels: 1K0-959-701-MIN2.lbl
   Part No: 1K0 959 701 K
   Component: Tuer-SG         024 2310 
   Coding: 0000564
   Shop #: WSC 01279 785 00200
   VCID: 3665694341C801A8CB0

1 Fault Found:
00932 - Electric Window Motor; Drivers Side (V147)
            005 - No or Incorrect Basic Setting / Adaptation - Intermittent

-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 1Kx-909-14x-44.clb
   Part No: 1K2 909 144 J
   Component: EPS_ZFLS Kl.1   D04 1606 
   Shop #: WSC 00000 000 00000
   VCID: 3363505752BA1480ECE

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv.        Labels: 1K0-959-433-MIN.clb
   Part No: 1K0 959 433 AJ
   Component:    KSG              0401 
   Coding: 18C802487F6D0C0DC85AC65010CC
   Shop #: WSC 12345 785 00200
   VCID: 78F9A77B0B5C37D819C

   Part No: 1K0 951 605 C
   Component: LIN BACKUP HORN H03 1301

   Part No: 1K0 907 719 B
   Component: Neigungssensor  004 0003

   Part No: 1K0 951 177 A
   Component: Innenraumueberw.005 0202

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass.        Labels: 1K0-959-702-MIN2.lbl
   Part No: 1K0 959 702 K
   Component: Tuer-SG         024 2310 
   Coding: 0000564
   Shop #: WSC 01279 785 00200
   VCID: 377B644746C2F8A0D06

2 Faults Found:
00097 - Front Passengers Central Locking (Safe) Motor (V162)
            012 - Electrical Fault in Circuit
00929 - Locking Module for Central Locking; Front Passenger Side (F221)
            008 - Implausible Signal

-------------------------------------------------------------------------------
Address 56: Radio (J0506)       Labels: 1T0-035-680.clb
   Part No SW: 1T0 035 680 B    HW: 1T0 035 680 B
   Component: RNS-MID       H03 0800 
   Revision: AB001001    Serial number: VWZ6Z7H7178053
   Coding: 040004000400001200
   Shop #: WSC 00020 790 00000
   ASAM Dataset: ------------------------- ------
   VCID: 2D57462F749E4270BAA

3 Faults Found:
00856 - Radio Antenna
            011 - Open Circuit
03138 - Input AUX IN
            011 - Open Circuit - Intermittent
01299 - Diagnostic Interface for Data Bus (J533)
            004 - No Signal/Communication
Logged

Offline rich83

  • Just look at my post count
  • ******
  • Thank You
  • -Given: 165
  • -Receive: 802
  • Posts: 13444
    • MK5 Golf GTI
  • My Ride: https://www.mk5golfgti.co.uk/forum/index.php?PHPSESSID=sqc6bmq69o5deci8udtf2d703t&/topic,19740.0.html
Re: Spluttering gti under load
« Reply #12 on: April 20, 2013, 10:03:37 pm »
So no fault codes under the 01-ENGINE label?
Logged

Offline rich golf gti mk5

  • Always Involved
  • ****
  • Thank You
  • -Given: 5
  • -Receive: 2
  • Posts: 89
    • Email
Re: Spluttering gti under load
« Reply #13 on: April 20, 2013, 10:09:35 pm »
nope. do u hae any idea what this points to. sparkplugs coil packs etc
Logged

Offline rich83

  • Just look at my post count
  • ******
  • Thank You
  • -Given: 165
  • -Receive: 802
  • Posts: 13444
    • MK5 Golf GTI
  • My Ride: https://www.mk5golfgti.co.uk/forum/index.php?PHPSESSID=sqc6bmq69o5deci8udtf2d703t&/topic,19740.0.html
Re: Spluttering gti under load
« Reply #14 on: April 20, 2013, 10:11:04 pm »
Well.. bit of an odd one. Usually spark related misfires are logged in the ECU.
Logged
Pages: [1] 2 3   Go Up
« previous next »